Whole-home duct cleaning
Dryer vent cleaning
Camera inspection
Sanitizing & deodorizingWhole-system duct and dryer vent check with before-and-after photos - you see exactly what came out of your vents
That "$99 whole-house special" is a bait ad - the real number appears once they are in your hallway, or the "clean" is a shop-vac at the register. We photograph the inside of your ducts before and after instead.
Trusted Air Duct Repair for Greeley Homeowners
If your energy bill jumped and some rooms never get warm, the problem may be in the ductwork itself, not the furnace. Air duct repair in Greeley fixes what cleaning alone can’t: crushed flex runs, seams that leak, joints that pulled apart behind the drywall, and sections a remodel left disconnected. We diagnose the actual fault with visual inspection and airflow checks, then repair it with the same team that cleans the system. That combined capability is what sets us apart from cleaning-only operators, and it’s why our technicians, with up to 12 years of experience, can tell you whether a run needs sealing, resizing or full replacement. Same-day repair is often possible. Call (833) 467-7154 to get on the schedule.
HVAC Duct Installation
HVAC Duct Installation means building new duct runs for an addition, a room conversion, a finished basement or a system that was never ducted properly in the first place. You need it when a space has no supply or return, when a previous installation undersized the trunk, or when a remodel opened up walls and made access practical. We handle this ourselves rather than referring it out, so the layout, sizing, sealing and tie-in all get checked by the same people. Typical HVAC duct installation work in Greeley runs $850-$2,800 depending on the number of runs and how much attic or crawlspace access the house allows; once walls close up again, that number climbs. The written estimate sets the final price before any work starts.
Sizing and Layout
Duct sizing isn’t guesswork. We calculate run lengths and branch sizes against the blower output so the new runs deliver the airflow the room actually needs, not whatever fits the hole. Get that wrong and the far room stays cold no matter how hard the furnace works.
Sealing New Joints
Every joint, collar and boot we install gets sealed, not just taped. Mastic and foil-backed tape on a properly fitted connection is the difference between a duct that lasts and one that leaks into the attic within a few seasons.
Styles & brands we work with
- Whole-home duct cleaning
- Dryer vent cleaning
- Camera inspection
- Sanitizing & deodorizing
Air Duct Replacement
Air Duct Replacement is the step after repair stops making sense: a stretch of duct that has deteriorated past the point where sealing or patching holds. That covers collapsed flex duct, rusted-out galvanized runs, duct board that’s been water-damaged, and flex that’s been crushed flat by storage or a careless trade. If we find that during an inspection, we’ll show you the section and explain what’s failed rather than just quoting a number. Air duct replacement in Greeley typically runs $600-$2,400 for a section and $2,500-$6,500 for a larger portion of the system, depending on length, material and access. We contain the work area with Abatement Technologies filtration so dislodged debris doesn’t travel through the house. The written estimate is set before we open anything up.
Flex Versus Rigid
Flex duct is fast to install and fine for short, straight runs, but it sags and pinches where it’s unsupported. Rigid pipe holds its shape and delivers stronger airflow over longer distances, which matters in older Greeley homes with generous attic runs.
What We Do With Old Duct
Removed duct leaves the house with us. We cut it down, bag it, and haul it out as part of the job so you’re not left with a pile in the garage or attic.
Ductwork Repair
Ductwork Repair is the catch-all for the problems that show up once you can actually see inside the system: disconnected joints, torn flex, separated seams, crushed runs and gaps at the boot where the duct meets the register. Most of these never show themselves until airflow drops or the utility bill climbs. We find them with a visual walk-through of the attic, crawlspace and mechanical closet, and we repair them in the same visit whenever the parts permit. Ductwork repair in Greeley usually runs $180-$650, depending on how many spots need attention and how hard they are to reach. Before-and-after photos of the repair are yours to keep, so you know exactly what was fixed.
Finding Disconnected Runs
A run that’s come loose at the trunk leaks conditioned air into the attic instead of the bedroom. We trace each visible run from register to trunk so a break behind insulation doesn’t go unnoticed.
Sealing Without Overpromising
Where a seam is failing, sealing it properly is cheaper than replacing the section, and we’ll say so. Where the duct material itself is gone, sealing won’t hold and we’ll tell you that too.
Duct Replacement
Duct Replacement means swapping out a whole system rather than patching sections, and it usually comes up after a major renovation, a full HVAC changeout, or an inspection that finds most of the ductwork in poor shape. If more than about half the runs show the same failure, piecemeal repair stops being good value. We handle duct replacement in Greeley with a full plan: what comes out, what goes back in, how the new system gets sealed and how the work area stays contained. Duct replacement costs typically run $2,500-$6,500 depending on square footage, number of runs and how much of the old system is accessible. One flat price per system, agreed before work starts. The written estimate sets the final figure.
When Whole-System Makes Sense
If sealing and replacing individual runs would cost most of what a full replacement costs, it’s worth hearing the comparison. We’ll run both numbers for you rather than pushing the bigger job.
Working Around Your Home
Replacement means a lot of movement through the house. We cover floors on the path to the attic access, keep tools contained, and use our Abatement Technologies filtration to keep dust where it belongs.
Ductwork Installation
Ductwork Installation covers the new-build and addition side of the work: laying out trunk lines, cutting in branches, setting boots and returns, and sealing the whole assembly before the drywall goes up. You need it when a room has no duct, when a system is being extended, or when a renovation removed and rebuilt a section of the ceiling. We use Rotobrush and Nikro equipment for the cleanup and verification that follows installation, so the new duct starts clean and stays that way. Ductwork installation in Greeley typically costs $850-$3,200 depending on how many runs, whether return air is included, and the amount of attic access. Free estimate before anything is cut or ordered.
Working With Your Contractor
On new construction and remodels we coordinate with the framing and drywall schedule so the ducts are in and sealed, but not buried. That saves rework on both sides.
Testing the New System
Once the new runs are in, we check airflow at the registers to confirm each one is delivering. A duct that’s installed but underperforming isn’t finished.
Brands We Service
We work on all duct and filter setups, and we’re specifically familiar with the filtration and air-quality hardware that Greeley homeowners already own. Honeywell and Aprilaire filtration systems sit on a lot of local furnaces, and we know where those assemblies wear out and how to work around them without disturbing the setup.
Aprilaire media cabinets and Honeywell electronic air cleaners both need to be handled correctly during cleaning and repair, or the filter housing gets misaligned and the system starts bypassing. We’re careful with Guardsman and Abatement Technologies equipment for the same reason. Whether you have a Honeywell setup, an Aprilaire cabinet, or any other make, we can help with the ductwork around it.
See the difference
Before
After
Before
After
Before
AfterSigns You Need a Pro Right Now
- Rooms that won’t heat or cool evenly. If one room is always cold while the rest of the house is fine, a disconnected or crushed run is a likely cause. It’s a quick diagnostic for us and gets worse on its own when left alone.
- A whistling or rumbling vent. Whistling means restricted airflow, and a rattle or rumble can mean a joint has come loose and is vibrating. Both signal a problem in the duct, not the furnace.
- Visible dust around a register. Dust trails at the grille point to a leak right behind it. That gap is sending air into the ceiling cavity and pulling attic dust into the room.
- Rising utility bills with no other change. A duct that leaks outright conditions the attic. The furnace works harder, and the cost shows up on the bill.
- Ductwork you can see is torn or crushed in the attic. Crushed flex is a common finding after storage, a roof job or a prior install. Repairing it restores airflow and pays back on the utility bill.
Our Process, Step by Step
- 1
Free estimate and walk-through. We look at the visible system, ask about symptoms, and talk through what we see before anyone commits. No diagnostic fee, and the price is set by the written estimate.
- 2
Inspection with the right tools. We trace supply and return runs, check each accessible connection, and verify airflow at the registers. Where the problem isn’t visible, we explain what a camera inspection can tell you and what it would cost.
- 3
Containment before we work. Abatement Technologies air filtration goes in before anything gets cut, so dislodged debris is captured instead of redistributed into the house.
- 4
Repair or replacement, same team. If we’re cleaning and find damage, we repair it. If the section needs replacing, we quote it and get your approval before cutting.
- 5
Verification and photos. We check airflow after the work, clean up with Nikro HEPA equipment, and leave you before-and-after photos of what we fixed.
How Much Does Air Duct Repair Cost in Greeley?
Air duct repair in Greeley typically runs $180-$650 for a spot repair, and the price depends mostly on how many breaks we find and how hard they are to reach. A typical single disconnected flex run or crushed section is at the low end. A multi-spot job with attic work and access issues runs higher. If the damage is broad, air duct replacement in the $600-$2,400 range covers a section, and a full system swap typically lands between $2,500 and $6,500.
What affects the price: the number of problem spots, the type of duct (flex, rigid or duct board), attic or crawlspace access, whether return air is involved, and whether the work is repair or replacement. An inspection that finds more than expected will change the number, and we’ll show you what we found rather than just quoting a bigger figure.
How to avoid overpaying: get the scope in writing before any cutting starts. Ask what’s included and what isn’t. The free estimate here spells out the specific repairs and the price for each, before any tool goes into the duct.
Our Service Area Near Greeley
We cover Greeley and the surrounding northern Front Range, with scheduled service into Firestone, Fort Lupton, Fort Collins, Longmont, Lochbuie, Dacono, Erie, Niwot and Todd Creek. Drive times vary with traffic, but most of the surrounding towns are reachable the same day. If you’re nearby and want the same standard of work on duct cleaning in Greeley, that’s a separate booking and we’ll sort it at the same time.
Serving Greeley, CO – Our Local Coverage Area
We serve Greeley and nearby communities. Use the map below to see the area we cover. If you’re nearby, we can almost certainly help.
Frequently Asked Questions About Air Duct Repair in Greeley
Air duct repair fixes the physical ductwork: disconnected joints, torn flex, crushed runs, separated seams and gaps at the register boot. It’s different from duct cleaning, which removes debris from inside a duct that’s already in good shape. Where cleaning uncovers a broken connection, we repair it on the same visit.
A single spot repair is often a couple of hours. Multiple repairs through a larger home can take most of a day, especially when attic access is tight. We give a time estimate with the written quote so you can plan the day.
Typical costs run $180-$650 for spot repairs, $600-$2,400 for a section replacement, and $2,500-$6,500 for a full system. Call (833) 467-7154 for an exact quote; estimates are free.
We use Rotobrush and Nikro equipment on every job as our own tools, and we clean systems built around them. If you’ve had a prior cleaning with those systems and something isn’t right, we can take a look.
Same-day repair is often available, and dispatch runs 7am to 7pm, Sunday through Friday. We answer 24/7, and we’re closed Saturday. A call outside dispatch hours is booked into the next opening.
Workmanship on our repairs is backed by a warranty, and the written estimate spells out what’s covered and for how long before you approve anything. We’ll walk you through it at the quote.
Clear the path to the attic or crawlspace access and move anything stored around it. Note which rooms feel off so we can target those runs. Close the filter check off the list too, since we’ll want to see the filter and its housing.
Schedule Your Air Duct Repair Service in Greeley Today
If your ductwork is leaking, crushed or disconnected, the cost of waiting is more than a small repair ticket. Call (833) 467-7154. We answer 24/7, dispatch runs 7am to 7pm, Sunday through Friday, and the estimate is free with no obligation. Professional-grade equipment, one flat price per system agreed before work starts, and before-and-after photos of your own duct. We fix what we find, not just what we’re asked about.
Written by the team at Duct Cleaning Greeley.